General Ford Ranger Discussion General discussion of the Ford Ranger that does not fit in any other sub-forum.
Sponsored by:
Sponsored by: DashLynx

Engine heating up at stops. Never goes over halfway, but I can smell coolant

Thread Tools
 
Search this Thread
 
  #1  
Old 08-14-2018
Modestodude's Avatar
Member
Thread Starter
Join Date: Aug 2018
Location: Modesto, CA
Posts: 3
Likes: 0
Received 0 Likes on 0 Posts
Engine heating up at stops. Never goes over halfway, but I can smell coolant

I have a Mazda b2300, 2.3 with around 200,000 miles.
Runs great, but It occasionally heats up when moving, but very rarely. Usually just in traffic, or at stops with a/c on .cools right off when the ac is turned off, or heated is turned on. It cools very quickly actually. When I spray the radiator with cool water it has little effect. I flushed the radiator, replaced the thermostat and cleaned the front of the radiator.
It’s always ran very cool.
The water pump seems to be working. I think it’s radiator. Is there a test for that?
 
  #2  
Old 08-14-2018
Modestodude's Avatar
Member
Thread Starter
Join Date: Aug 2018
Location: Modesto, CA
Posts: 3
Likes: 0
Received 0 Likes on 0 Posts
It’s a 1995
 
  #3  
Old 08-14-2018
Apexkeeper's Avatar
RF's Exiled Elite
Join Date: Dec 2017
Location: Kentucky
Posts: 553
Likes: 0
Received 4 Likes on 4 Posts
If its only over heating when stopped I'd check your fan clutch. Inspect it for signs of wetness (oil leaks), physically grab it and feel for play, and spin the fan by hand ( it should have some resistance and not free spin).
 
  #4  
Old 08-14-2018
RonD's Avatar
RF Veteran
iTrader: (1)
Join Date: Jan 2014
Location: Vancouver, BC
Posts: 30,654
Received 2,820 Likes on 2,586 Posts
Yes, +1

Rising temp gauge while stopped is classic sign of Failing Fan Clutch
Can also be water pump impeller issue but much less likely


The fan is only there to provide air flow thru the radiator in stop and go traffic or when vehicle is not moving.
 
  #5  
Old 08-14-2018
Modestodude's Avatar
Member
Thread Starter
Join Date: Aug 2018
Location: Modesto, CA
Posts: 3
Likes: 0
Received 0 Likes on 0 Posts
Originally Posted by Apexkeeper
If its only over heating when stopped I'd check your fan clutch. Inspect it for signs of wetness (oil leaks), physically grab it and feel for play, and spin the fan by hand ( it should have some resistance and not free spin).
I had the fan clutch off when I changed the thermostat. It barely spun, plenty of resistance. Is it supposed to spin pretty easily?
 
  #6  
Old 08-14-2018
00GreenRanger's Avatar
Level III Supporter
Join Date: Nov 2011
Location: North Bend, WA
Posts: 1,350
Likes: 0
Received 2 Likes on 2 Posts
Also the sign of a cracked head/bad head gasket. Keep an eye on your coolant level.
 
  #7  
Old 08-15-2018
RonD's Avatar
RF Veteran
iTrader: (1)
Join Date: Jan 2014
Location: Vancouver, BC
Posts: 30,654
Received 2,820 Likes on 2,586 Posts
Originally Posted by Modestodude

I had the fan clutch off when I changed the thermostat. It barely spun, plenty of resistance. Is it supposed to spin pretty easily?







When COLD the fan clutch will be tight
Thats the noise you should hear when you start a cold engine, a louder rush of air from locked up fan clutch, then that noise goes away after a few seconds when the oil inside the fan clutch gets warm from spinning.
Then the fan should spin easily, so start engine, let it run for 30 seconds then shut it off, fan should spin easily now.

Then drive it for 15-20 minutes, shut it off and fan should be tighter, you can move it but not spin it, if not then replace fan clutch.


The fan clutch works from RADIATOR HEAT, not engine heat, on the front of fan clutch is a bi-metal spring, as it heats up from hot coolant circulation in the radiator it closes off a valve in the clutch, which causes fan to spin closer to engine RPMs, it never fully locks, just gets tighter and tighter as radiator temp gets hotter.

When driving, the engine is under a Load, so gets hotter, when you stop, the heat from that Load is still there for a minute or two, but lower RPMs(idle) circulates less coolant, and lower speed causes less air flow thru radiator to dissipate that heat, so you have more heat and less cooling.
That is really the only reason there is a fan for cooling radiator, low speeds and when stopped is when the fan is needed, so heating up at idle would be a problem with.......................the fan
This is also why electric fans are a popular choice, mechanical fan uses horsepower all the time, but only needed maybe 5% of the time

There are a few of reasons an engine will get hotter at idle:
1. Fan clutch failing is at the top of the list and most common reason

2. If center of radiator is clogged up, fan clutch never get hot enough so never engages fully

3. General blockage causing low flow thru radiator

4. Leafs and debris clogging up air flow thru radiator

5. If water pump impeller is eaten away by electrolysis, it can't circulate coolant fast enough at lower RPMs

6. A lean fuel mix at idle

7. Failing spark advance at idle
 

Last edited by RonD; 08-15-2018 at 09:43 AM.
Related Topics
Thread
Thread Starter
Forum
Replies
Last Post
Takachakaka
General Ford Ranger Discussion
2
05-06-2018 06:54 PM
bsan84
4.0L OHV & SOHC V6 Tech
1
03-25-2015 06:51 PM
ShawnInFL
General Ford Ranger Discussion
16
10-05-2013 02:12 PM
19ranger19
2.9L & 3.0L V6 Tech
2
09-21-2011 01:41 PM
Bigdank
4.0L OHV & SOHC V6 Tech
19
01-01-2008 06:14 PM



Quick Reply: Engine heating up at stops. Never goes over halfway, but I can smell coolant



All times are GMT -6. The time now is 07:53 AM.