Interior, Exterior, & Electrical How-To & DIY articles pertaining to the 'Interior, Exterior, & Electrical' in this sub-forum.

How To: Install A Protrax Retractable Tonneau Cover

Thread Tools
 
Search this Thread
 
  #1  
Old 11-24-2010
korey89's Avatar
Member
Thread Starter
iTrader: (2)
Join Date: Mar 2008
Location: South, FL
Posts: 4,672
Likes: 0
Received 5 Likes on 5 Posts
How To: Install A Protrax Retractable Tonneau Cover

Here is how to install a Protrax retractable tonneau cover.

Install time is about an hour and you will need a friend to help you. No special tools are needed, all you need is a socket and ratchet for the clamps, a tape measure, and a #2 phillips head screwdriver.

Name:  2.jpg
Views: 305
Size:  61.2 KB
Here is what you're going to see when you open the packages. The canister for the tonneau, two rails, a cover for the canister, instructions, drain tubes, keys, and a box containing clamps and a few pieces of hardware.

Name:  3.jpg
Views: 299
Size:  55.2 KB
The included hardware and drain tubes

Name:  5.jpg
Views: 280
Size:  57.8 KB
Here is a picture of the side of the canister, you can see it is all ball bearings and you can see how it works.

Name:  7.jpg
Views: 269
Size:  42.8 KB
This is a bracket for shipping, it needs to come off.

Name:  8.jpg
Views: 296
Size:  31.8 KB
Remove the phillips head screw.


Now remove it and discard.


Next, the plastic tube needs to come out. Simply pull it out and discard it.

Name:  11.jpg
Views: 265
Size:  67.9 KB
Now repeat on the other side, being careful to not allow the cover to roll inside the canister.

Name:  12.jpg
Views: 294
Size:  70.8 KB
Now it is time to attach the bed rails. Place one rail and the canister on a soft surface to avoid any scratching.

Name:  13.jpg
Views: 275
Size:  73.3 KB
Place the bedrail in place so the tabs align and insert the two provided screws. DO NOT USE LOCTITE.

Name:  14.jpg
Views: 285
Size:  66.8 KB
You can see the tonneau has to be rolled out a little bit too, here is another view of it installed.

Name:  15.jpg
Views: 299
Size:  72.2 KB
Repeat on the other side.

Name:  16.jpg
Views: 299
Size:  49.2 KB
Now install the canister cover.

Name:  17.jpg
Views: 276
Size:  34.5 KB
One phillips head screw on each side. Also DO NOT USE LOCTITE.

Name:  18.jpg
Views: 283
Size:  53.6 KB
Now with the help of a partner lift and place the cover in place making sure it's all the way back.

Name:  20.jpg
Views: 268
Size:  47.1 KB
Now use the provided piece of aluminum to get the correct gap on each end.


Install the front clamps, placing them in between the two plastic adjustment screws. Be sure that they are pushed all the way up.

Name:  22.jpg
Views: 281
Size:  60.0 KB
Install the rear clamps also placing them in between the plastic adjustment screws.

Name:  23.jpg
Views: 251
Size:  33.9 KB
Now we need to measure to make sure the rails are parallel with each other. You will need a tape measure and a pen.

Name:  24.jpg
Views: 248
Size:  21.5 KB
Measure the gap in the three locations noted in the instructions and record the distances. Adjust the plastic adjustment screws as needed. In my installation everything was square and I did not need to adjust them.

Name:  25.jpg
Views: 257
Size:  30.9 KB
You can verify it is adjusted right by rolling the cover closed and looking at the felt strip at the end. The amount of felt exposed on each end should be the same.

Name:  27.jpg
Views: 285
Size:  41.2 KB
Next remove the protective plastic cling wrap.

Name:  28.jpg
Views: 307
Size:  89.3 KB
The felt washers need to be installed on the drain tubes.

Name:  29.jpg
Views: 265
Size:  42.9 KB
Install the drain tubes and you're done. You may need to drill two small holes in your bed if you don't have any existing ones you can use.

Name:  26.jpg
Views: 306
Size:  59.0 KB
DONE! Enjoy your new cover!


Here is a video showing the operation of the cover and how it locks. You can see you can lock it in any position, unlike most other ones. The cover also locks with a key which stops the handle from lifting. It is unlocked for video purposes.


For more info click the logo below. They also offer the "Retrax" is which a lexan constructed version. It is offered in black, silver, and also a power opening electric version.
 

Last edited by 98liftedranger; 12-02-2011 at 08:53 AM.
Related Topics
Thread
Thread Starter
Forum
Replies
Last Post
CADreamin
OLD - Interior, Exterior, Electrical, & Misc.
1
11-19-2012 12:02 PM
korey89
Interior, Exterior, & Electrical
0
11-15-2008 11:55 PM
pacodiablo
General Ford Ranger Discussion
17
09-19-2004 10:17 AM
straightedge
Exterior Semi-Tech
16
06-15-2004 06:51 AM



Quick Reply: How To: Install A Protrax Retractable Tonneau Cover



All times are GMT -6. The time now is 01:46 AM.