All TSB's For 2001 Ford Ranger - Ranger-Forums - The Ultimate Ford Ranger Resource


General Technical & Electrical General technical and electrical discussion for the Ford Ranger that does not fit in any other sub-forum.

Reply
 
LinkBack Thread Tools Search this Thread
  #1  
Old 05-03-2005
Member
Thread Starter
 
Join Date: Apr 2005
Location: Shelbyville, Kentucky
Posts: 1,101
All TSB's For 2001 Ford Ranger

Technical Service Bulletins
2001 RANGER - US (English)


05-9-18
DISCHARGED BATTERY - CHARGING SERVICE TIPS

05-6-20
FRONT AXLE LEAKS FLUID FROM VENT TUBE - VEHICLES EQUIPPED WITH 4X4 OR AWD

05-3-10
SAFETY BELT WEB STOP BUTTON SERVICE

05-1-3
INSIDE DOOR PULL HANDLE LOOSE - VEHICLES BUILT BEFORE 11/15/2002 AND EQUIPPED WITH POWER WINDOWS/DOOR LOCKS

04-25-1
ALUMINUM CORROSION - SERVICE TIP

04-24-21
SAFETY BELT RETRACTION SPEED

04-24-19
REVISED PROCEDURE FOR ADJUSTING ALIGNMENT ON ALL SUSPENSIONS - NEW RIGHT HAND UPPER CONTROL ARM DESIGN FOR TORSION BAR FRONT SUSPENSIONS

04-24-14
GENERAL PCM PROGRAMMING PROCEDURES

04-24-3
LEATHER-WRAPPED STEERING WHEEL - LEATHER COMING LOOSE

04-23-7
DRIVESHAFT - THUMP/CLUNK ON LIGHT ACCELERATION FROM STOP OR WHEN BRAKING AND COMING TO A STOP - RANGER 4X4 SUPER CAB

04-17-4
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS

04-15-4
RATTLE NOISE FROM PRIMARY CHAIN DRIVE AREA 2000-3000 RPM - 4.0L SOHC ENGINE

04-11-1
DRIVEABILITY - STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MIL ON AND DTCS P0401, P0402, P1400 OR P1401 - ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY

04-8-6
ENGINE - BOOM/VIBRATION AT 1800-2200 RPM - ROUGH IDLE - 2.3L ENGINE
VIBRATION - BOOM/VIBRATION AT 1800-2200 RPM - ROUGH IDLE - 2.3L ENGINE

04-6-2
ENGINE - LOWER ENGINE OIL LEAKS - 3.0L 2V VULCAN ENGINE - DIAGNOSTIC SERVICE TIPS

04-2-4
BODY - SAFETY BELT PRETENSIONER DIAGNOSTIC TROUBLE CODES (DTC) B1877 AND/OR B1881
ELECTRICAL - SAFETY BELT PRETENSIONER DIAGNOSTIC TROUBLE CODES (DTC) B1877 AND/OR B1881

03-23-5
BODY - BED EXTENDER - COMPONENT REPLACEMENT - SERVICE TIP

03-23-1
BODY - TONNEAU COVER LATCH AND STRUT DIAGNOSTICS - CUSTOMER INSTRUCTIONS FOR REMOVAL/INSTALLATION

03-22-10
TRANSMISSION - 4R44E - 4R55E - 5R44E - 5R55E - LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT) - POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 - VEHICLES BUILT BEFORE 12/1/2001

03-20-3
DRIVEABILITY - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DTC'S P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457

03-18-1
ELECTRICAL - REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS

03-14-8
TRANSMISSION - NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS

03-11-6
ELECTRICAL - WIRING - SOLDERING AND CRIMPING REPAIRS - SERVICE TIPS

03-9-4
BRAKES - BRAKE PULL - 4X2 (NON-EDGE), COIL SPRING EQUIPPED RANGER ONLY

03-5-3
ENGINE - 3.0L 2V (VULCAN) REVISED OIL PAN GASKET REPLACEMENT PROCEDURE - NEW SERVICE KIT - SERVICE TIP

03-3-5
DRIVEABILITY - IDLE AIR CONTROL (IAC) VALVE DIAGNOSTIC SERVICE TIPS

02-25-5
SEAT - DRIVER AND/OR PASSENGER SEAT TRACK "RATTLING"
NOISE - "RATTLING" COMING FROM DRIVER'S AND/OR PASSENGER'S SEAT TRACK

02-25-2
ELECTRICAL - CDX6 RADIO DAMAGED DURING SERVICE SHIPPING - CORRECT SHIPMENT PROCEDURES FOR CDX6 RADIO - SERVICE TIPS

02-23-4
DIAGNOSTIC TROUBLE CODE (DTC) - P1635 AND/OR P1639 PRESENT AFTER POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER REPLACEMENT - GASOLINE ENGINE VEHICLES ONLY
LAMP - 4X4 LAMP ILLUMINATED AFTER POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER REPLACEMENT - GASOLINE ENGINE VEHICLES ONLY
SPEEDOMETER - INACCURATE AND/OR INOPERATIVE AFTER POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER REPLACEMENT - GASOLINE ENGINE VEHICLES ONLY

02-23-2
BODY - FRAME MOUNTED FRONT BUMPER BRACKETS SERVICE KIT

02-22-2
NOISE - GEAR WHINE NOISE IN 1ST AND 2ND GEAR ONLY - VEHICLES EQUIPPED WITH 5R55E TRANSMISSION AND 4.0L ENGINE ONLY
TRANSMISSION - 5R55E - GEAR WHINE NOISE IN 1ST AND 2ND GEAR ONLY - VEHICLES EQUIPPED WITH 4.0L ENGINE ONLY

02-22-1
DRIVEABILITY - SURGE/ROLLING IDLE - GEAR DRIVEN SYNCHRONIZERS - INCORRECT INSTALLATION - CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION
ENGINE - GEAR DRIVEN SYNCHRONIZERS - INCORRECT INSTALLATION - CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION

02-21-13
ENGINE - STRAIGHTEDGE PROCEDURE FOR CHECKING CYLINDER HEAD AND BLOCK FLATNESS

02-19-1
THUMP/BUMP ON ACCELERATION FROM A STOP OR WHEN BRAKING FROM DRIVESHAFT AREA - 4X2 AUTOMATIC TRANSMISSION SUPER CAB EDGE MODELS ONLY

02-17-6
LAMP - BRAKE - INADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK


02-16-4
FUEL SYSTEM - FUEL PUMP "WHINING"/"BUZZING" NOISE COMES THROUGH ENTERTAINMENT OR TWO-WAY RADIO SPEAKER
RADIO - ENTERTAINMENT OR TWO-WAY COMMUNICATION - "WHINING"/"BUZZING" NOISE IN SPEAKERS CAUSED BY FUEL PUMP
NOISE - "WHINING"/"BUZZING" - COMES THROUGH SPEAKERS OF ENTERTAINMENT OR TWO-WAY RADIO

02-8-3
TRANSMISSION - 5R44E OR 5R55E - FLUID LEAK AT SERVO COVER - VEHICLES PRODUCED 6/1/2001 THROUGH 3/31/2002 EQUIPPED WITH 2.3L, 3.0L OR 4.0L ENGINES

02-6-5
ELECTRICAL - ELECTRIC VEHICLE (EV) RANGER COLD WEATHER BATTERY PERFORMANCE

02-5-5
NOISE - "HOOTING," "EEKING," OR "MOANING" NOISE COMING FROM CLUTCH WHEN SHIFTING GEARS
CLUTCH - "HOOTING," "EEKING," OR "MOANING" NOISE COMING FROM CLUTCH WHEN SHIFTING GEARS

02-3-5
BODY - "SQUEAK" OR BIND FROM TAILGATE
NOISE - "SQUEAK" OR BIND FROM TAILGATE

02-3-2
DRIVEABILITY - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTC) P0300/P0301 STORED IN MEMORY - VEHICLES EQUIPPED WITH 4.0L SOHC ENGINE ONLY
ELECTRICAL - LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTC) P0300/P0301 STORED IN MEMORY - VEHICLES EQUIPPED WITH 4.0L SOHC ENGINE ONLY
ENGINE - 4.0L SOHC - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTC) P0300/P0301 STORED IN MEMORY - VEHICLES EQUIPPED WITH 4.0L SOHC ENGINE ONLY

02-1-9
ENGINE - ENGINE OIL - RECOMMENDED APPLICATIONS FOR SAE 5W-20 AND SAE 5W-30 MOTOR OILS - GASOLINE AND FLEXIBLE FUEL VEHICLES ONLY

01-24-6
ENGINE - ENGINE OIL SYSTEM PRIMING PROCEDURES - SERVICE TIPS

01-24-1
CLUTCH - CLUTCH PEDAL STAYS ON FLOOR - NOT ABLE TO DISENGAGE CLUTCH - FLUID LEAK FROM HYDRAULIC CLUTCH LINE

01-23-6
ENGINE COOLANT - PROPYLENE GLYCOL - FORD MOTOR COMPANY POSITION ON ENGINE COOLANTS MADE FROM PROPYLENE GLYCOL
ENGINE COOLANT - PROPYLENE GLYCOL-BASED - FORD MOTOR COMPANY POSITION ON PROPYLENE GLYCOL-BASED ENGINE COOLANTS

01-23-2
DRIVEABILITY - IDLE - LOW ENGINE RPM DURING INITIAL COLD START OR LOSS OF ENGINE POWER AFTER CLUTCH DISENGAGEMENT OR ON DECELERATION - VEHICLES EQUIPPED WITH 4.0L SOHC ENGINE ONLY
DRIVEABILITY - STALL - LOSS OF ENGINE POWER AFTER CLUTCH DISENGAGEMENT OR ON DECELERATION - VEHICLES EQUIPPED WITH 4.0L SOHC ENGINE ONLY

01-21-13
DRIVEABILITY - DIAGNOSTIC TROUBLE CODES (DTC) P0500, P1502 AND/OR U1039 CONTINENTAL MODELS ONLY - STICKING OR BINDING IGNITION LOCK CYLINDER - HIGH EFFORT WHEN TURNING IGNITION SWITCH
ELECTRICAL - STICKING OR BINDING IGNITION LOCK CYLINDER - HIGH EFFORT WHEN TURNING IGNITION SWITCH

01-20-4
ENGINE - 3.0L 2V VULCAN - ENGINE OIL LEAK AT OIL FILTER SEAL AREA - ENGINES PRODUCED AT LIMA ENGINE PLANT 8/1/2000 THROUGH 10/10/2000 ONLY

01-19-3
ELECTRICAL - ELECTRIC VEHICLE - DIAGNOSTIC TROUBLE CODE (DTC) B2785 AND/OR POWER LIMITED MODE OPERATION - ELECTRIC RANGER AND ELECTRIC POSTAL VEHICLES ONLY

01-18-7
DRIVEABILITY - UNABLE TO REACH WIDE OPEN THROTTLE (WOT) - LACK OF POWER

01-18-4
ELECTRICAL - SPEEDOMETER DROPS TO "0" MPH/KPH WHILE DRIVING - VEHICLES EQUIPPED WITH 2.5L ENGINE ONLY - VEHICLES PRODUCED BEFORE 12/31/2000

01-15-6
CLIMATE CONTROL - REPEAT HEATER CORE FAILURE
COOLING SYSTEM - REPEAT HEATER CORE FAILURE

01-14-3
ELECTRICAL - MOISTURE OR CONDENSATION IN FOG LAMPS - VEHICLES PRODUCED BEFORE 6/25/2001

01-13-8
TRANSMISSION - 5R44E - DELAYED REVERSE ENGAGEMENT - VEHICLES PRODUCED 8/8/2000 THROUGH 6/18/2001 EQUIPPED WITH 3.0L ENGINE ONLY

01-13-3
SUSPENSION - REAR SHOCK SPACER WASHER USAGE - ELECTRIC VEHICLES (E.V.) PRODUCED AFTER 4/1/2001 ONLY

01-11-8
ELECTRICAL - ELECTRIC VEHICLES (E.V.) RANGER/POSTAL VEHICLES - NEW VERSION 3.0 DIAGNOSTIC SOFTWARE IS AVAILABLE

01-11-4
NOISE - "SQUEALING" OR "WHISTLING" NOISE FROM FRONT AXLE AREA - DRIVING AT SPEEDS OF 16-64 KM/H (10-40 MPH) - 4X4 VEHICLES ONLY - REVISED FRONT OUTER HALFSHAFT DUST SEALS
FRONT AXLE - "SQUEALING" OR "WHISTLING" NOISE FROM FRONT AXLE AREA - DRIVING AT SPEEDS OF 16-64 KM/H (10-40 MPH) - 4X4 VEHICLES ONLY - REVISED FRONT OUTER HALFSHAFT DUST SEALS

01-11-3
TRIM - INTERIOR REAR CORNER TRIM - MOUNTING HOLES DO NOT LINE UP CORRECTLY - POOR FIT - VEHICLES BUILT THROUGH 10/9/2000

01-11-2
ELECTRICAL - FUEL GAUGE - FUEL GAUGE DROPS FROM "FULL" TOO FAST - FUEL GAUGE INDICATES LESS THAN THE ACTUAL FUEL LEFT IN THE TANK - VEHICLES EQUIPPED WITH 2.3L, 3.0L GAS OR 4.0L SOHC ENGINE - VEHICLES PRODUCED BEFORE 3/26/2001 ONLY

01-10-12
WIRING - WIRE HARNESS TERMINAL REPAIR KIT AND WIRE SPLICE PROCEDURE

01-10-9
DRIVEABILITY - ELECTRIC VEHICLE (EV) - DIAGNOSTIC TROUBLE CODE (DTC) C1838 - BATTERY CHARGING DIAGNOSTICS SERVICE TIPS
ELECTRICAL - ELECTRIC VEHICLE (EV) - DIAGNOSTIC TROUBLE CODE (DTC) C1838 - BATTERY CHARGING DIAGNOSTICS SERVICE TIPS

01-10-3
ELECTRICAL - LAMP - FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND/OR A DELAYED 1-3 SHIFT - DIAGNOSTIC TROUBLE CODE P0733 - VEHICLES EQUIPPED WITH 5R44E/3.0L ONLY
TRANSMISSION - 5R44E - FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND/OR A DELAYED 1-3 SHIFT - DIAGNOSTIC TROUBLE CODE P0733 - 5R44E/3.0L ONLY

01-9-7
DRIVEABILITY - HO2S (HEATED OXYGEN SENSOR), CATALYST, AND FUEL SYSTEM MONITORS - SERVICE TIPS - OBD II VEHICLES ONLY

01-6-2
PASSIVE ANTI THEFT SYSTEM (PATS) - DIAGNOSTIC SERVICE TIPS

01-5-2
DRIVEABILITY - ROUGH IDLE - DIAGNOSTIC TROUBLE CODES (DTCS) P0500, P0501, P0503, P1721, P0176, OR P1000 STORED IN MEMORY - WATER INTRUSION AT CONNECTOR C309 OR C340 UNDER DRIVER'S SEAT - VEHICLES PRODUCED BEFORE 1/2/2001
ELECTRICAL - ANTI-LOCK BRAKE (ABS) LAMP ILLUMINATED - DIAGNOSTIC TROUBLE CODE (DTC) C1230 OR CODES 9 OR 16 STORED IN MEMORY - WATER INTRUSION AT CONNECTOR C309 OR C340 UNDER DRIVER'S SEAT - VEHICLES PRODUCED BEFORE 1/2/2001
ELECTRICAL - SPEEDOMETER - INOPERATIVE OR ERRATIC OPERATION - WATER INTRUSION AT CONNECTOR C309 OR C340 UNDER DRIVER'S SEAT - VEHICLES PRODUCED BEFORE 1/2/2001
TRANSMISSION - 4R44E - ROUGH/HARSH OR DELAYED UPSHIFT - WATER INTRUSION AT CONNECTOR C309 OR C340 UNDER DRIVER'S SEAT - VEHICLES PRODUCED BEFORE 1/2/2001

01-5-1
DRIVEABILITY - LACK OF POWER AFTER POWERTRAIN CONTROL MODULE (PCM) REPROGRAMMING - VEHICLES EQUIPPED WITH 3.0L OR 4.0L ENGINE
ENGINE - LACK OF POWER AFTER POWERTRAIN CONTROL MODULE (PCM) REPROGRAMMING - VEHICLES EQUIPPED WITH 3.0L OR 4.0L ENGINE

01-4-12
DRIVEABILITY - ELECTRIC RANGER (EV) - HIGH VOLTAGE INSULATED SAFETY GLOVES - TESTING AND ORDERING INFORMATION
ELECTRICAL - ELECTRIC RANGER (EV) - HIGH VOLTAGE INSULATED SAFETY GLOVES - TESTING AND ORDERING INFORMATION

01-4-6
BODY - POWER WINDOW - CHATTER OR BINDING WHEN OPERATING POWER SIDE WINDOWS - VEHICLES BUILT THROUGH 2/1/2001
ELECTRICAL - POWER WINDOW - CHATTER OR BINDING WHEN OPERATING POWER SIDE WINDOWS - VEHICLES BUILT THROUGH 2/1/2001

01-2-3
DRIVEABILITY - COLD START IDLE DIP - VEHICLES EQUIPPED WITH 4.0L SOHC AND AUTOMATIC TRANSMISSION - VEHICLES BUILT BEFORE 11/27/2000

00-26-2
LAMP - OIL WARNING LAMP ILLUMINATED - ELECTRIC VEHICLES ONLY
ENGINE - OIL WARNING LAMP ILLUMINATED - ELECTRIC VEHICLES ONLY

00-23-10
TRANSMISSION - FLUID IN-LINE FILTER KIT - REPEAT REPAIRS OF TRANSMISSION - SERVICE TIPS

00-22-4
ELECTRICAL - ELECTRIC VEHICLE (EV) - RANGER E.V. - DECLINING DRIVING RANGE - BATTERY RECOVERY AND CHARGING PROCEDURE

Last edited by Sad_Savant; 05-03-2005 at 08:00 PM.
Reply With Quote
  #2  
Old 05-03-2005
karrbass4life's Avatar
Member
 
Join Date: Nov 2004
Location: Cincinnati, Ohio
Posts: 3,072
omfg... thats all i can say
Reply With Quote
  #3  
Old 05-03-2005
Bigwill41's Avatar
Member
 
Join Date: Jun 2004
Location: Navasota, Texas
Posts: 4,659
wow...

What was all that about...

Edit: My truck had everyone of those probs...
Reply With Quote
Reply

Related Topics
Thread Thread Starter Forum Replies Last Post
TSB Info for 2 Pc. Driveshaft Sad_Savant Drivetrain Tech 38 11-11-2010 09:12 PM
09 Ranger TSB - Starter/Transmission 0RangerEdge2 General Ford Ranger Discussion 0 06-18-2009 01:51 AM
TSB 4.0 Timing Chain cincy4point0 General Ford Ranger Discussion 34 12-07-2005 10:32 PM
TSB for 2001 to 2003 Rangers! Sad_Savant Interior Semi-Tech 0 04-29-2005 07:49 PM
Anybody have access to TSB's? rngprerunner General Technical & Electrical 3 04-29-2005 03:26 PM


Thread Tools Search this Thread
Search this Thread:

Advanced Search

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are Off
Pingbacks are Off
Refbacks are Off



All times are GMT -6. The time now is 12:07 PM.


We are a participant in the Amazon Services LLC Associates Program, an affiliate advertising program designed to provide a means for us to earn fees by linking to Amazon.com and affiliated sites.